Product ID:GREEN ZINC CHROMATE PRIMER TT-P-1757
MSDS Date:02/05/1992
FSC:8010
NIIN:00F040719
MSDS Number: BXMGX

RANDOLPH PRODUCTS CO

701 12TH ST
CARLSTADT, NJ 07072-0830
US

Emergency Phone: 201-438-3700/800-255-3924

Info Phone: 201-438-3700/800-255-3924

Cage: 77672

RANDOLPH PRODUCTS CO

830 CARLSTADT, NJ 07072-0830 US

Telephone: 201-438-3700

Cage: 77672

POTASSIUM ZINC CHROMATE (HUMAN CARCINOGEN BY ACGIH, IARC -

CAS: 11103-86-9

RTECS: GA9170000

Fraction By Weight: <25%

ACGIH TLV: 0.01 MG/M3

RESIN

Fraction By Weight: <30%

PHENOLIC RESIN

Fraction By Weight: <5%

OSHA PEL 150 PPM

ACGIH TLV: 100 PPM

BUTANOL, N-BUTYL ALCOHOL, PROPYL CARBINOL, BUTYL ALCOHOL

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: <15%

OSHA PEL 100 PPM

ACGIH TLV: C 152 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TOLUENE (IARC CARC- GROUP 3) *95-2*

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: <10%

OSHA PEL 150 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE

CAS: 64742-89-8

Fraction By Weight: <20%

OSHA PEL 400 PPM

ACGIH TLV: 300 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. INHALATION: CNS
EFFECTS, DEATH.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:DRYING, CRACKING, IRRITATION, RASH, SCALING,
BLISTERING, HEADACHES, DIZZINESS, ANESTHETIC.
Medical Cond Aggravated by Exposure:PRE-EXISTING SENSITIVITY TO
SOLVENTS.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. SKIN:
FLUSH W/WATER. EYES: FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER.
INGESTION: DON'T INDUCE VOMITING. KEEP WARM & QUIET. OBTAIN MEDICAL
ATTENTION IN ALL CASES.

Flash Point Method:SCC
Flash Point:50F
Lower Limits:0.9
Upper Limits:67
Extinguishing Media:CO2, DRY CHEMICAL FOAM
Fire Fighting Procedures:WATER STREAM WILL SPREAD. REMOVE ALL
NONESSENTIAL PERSONNEL FROM AREA. DON'T USE WATER HOSE STREAM. WEAR
FULL BUNKER GEAR IN AREA.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT/SPARKS/OPEN FLAMES. CLOSED CONTAINERS MAY EXPLODE TO
EXTREME HEAT. WATER MAY BE USED TO COOL CONTAINERS.(SUPP)

Spill Release Procedures:AVOID BREATHING VAPORS. ENSURE ADEQUATE
VENTILATION. AVOID SPARKS/FLAMES/IGNITION SOURCES W/OUT RISK BY
CLOSING VALVE, PLUGGING HOLE. APPLY ABSORBENT INERT MATERIAL. CLEAN
W/BRISTLE BROOMS, NON-SPARKI NG TOOLS, CLEAN DRY RAGS. WEAR
PROTECTIVE CLOTHING

Handling and Storage Precautions:DRUMS SHOULD BE GROUNDED WHEN BEING
EMPTIED.
Other Precautions:PROVIDE RESPIRATORY PROTECTION AGAINST FUMES
GENERATED DURING BURNING. AVOID EYE/SKIN & CLOTHING CONTACT.

Respiratory Protection:NIOSH/OSHA APPROVED RESPIRATOR. APPROVED
CHEMICAL/MECHANICAL FILTERS RECOMMENDED WHEN VENTILATION IS
RESTRICTED.
Ventilation:SUFFICIENT VENTILATION
Protective Gloves:REQUIRED
Eye Protection:CHEMICAL GOGGLES W/SIDE SHIELDS
Other Protective Equipment:FACE SHIELD RECOMMENDED, PROTECTIVE CREAMS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. USE NORMAL HYGIENE PRACTICES DURING & AFTER HANDLING. WASH
THOROUGHLY
Supplemental Safety and Health
UNUSUAL FIRE CONT'D: VAPOR IS > THAN AIR & CAN TRAVEL CONSIDERABLE
DISTANCE TO IGNITION SOURCES & FLASHBACK.

Boiling Pt:B.P. Text:208-280F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:0
Appearance and Odor:THIN GREEN LIQUID W/TYPICAL SOLVENT ODOR
Percent Volatiles by Volume:69.5

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, ALKALIES
Stability Condition to Avoid:EXTREME HEAT, SPARKS, OPEN FLAMES
Hazardous Decomposition Products:CO, CO2

Waste Disposal Methods:SOAK LIQUIDS W/SAWDUST/RAGS & REMOVE. FLUSH
W/WATER IF POSSIBLE. AVOID SKIN CONTACT. DISPOSE OF IAW/FEDERAL,
STATE & LOCAL REGULATIONS. DON'T INCINERATE. TRANSFER TO CONTAINERS
FOR RECOVERY/DISPOSAL. EPA HAZARDOUS WASTE CODE F003.
IGNITABILITY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.